一、司炉工作必须操作经劳动部门发给使用登记证的锅炉。
1、 The stoker must operate the boiler with the use registration certificate issued by the labor department.
二、独立操作的司炉工人须持有司炉操作证，且符合操作炉型和类别要求。
2、 The stoker who operates independently must hold the stoker's operation certificate and meet the requirements of the type and type of furnace.
三、锅炉点火前应做好锅炉主体、燃烧机和其他辅机、所有附件、阀门、给水、供油系统电路和电控部门等检查，并确认正常。
3、 Before the ignition of the boiler, the main body of the boiler, combustion engine and other auxiliary equipment, all accessories, valves, water supply, oil supply system circuit and electric control department shall be inspected and confirmed to be normal.
四、打开放空气阀门，向炉内进水（可用排水的方法检查水位后控制，报警系统工作是否正常）水位略低于正常水位。
4、 Open the air release valve and feed water into the furnace (the water level can be controlled by means of drainage after checking the water level and whether the alarm system works normally). The water level is slightly lower than the normal water level.
五、用“手动”启动风机、吹扫炉膛，将控制系统调“自动”位置，然后按下启动开关，锅炉就会按照规定的程序：吹扫——点火——燃烧（大火或小火）——暂时停炉。如点火程序有故障，可继续手动风机吹扫，再重新点火。如点火三次不成功，须停止点火和供油。查明原因故障后，才能重新点火。
5、 Use "manual" to start the fan, purge the furnace, adjust the control system to "automatic" position, and then press the start switch, the boiler will follow the specified procedures: purging ignition combustion (large or small fire) - temporary shutdown. If there is a fault in the ignition procedure, the manual blower can continue to blow and then re ignite. If the ignition fails for three times, stop ignition and fuel supply. Find out the cause and eliminate the fault before re ignition.
六、当锅内压力升稍大与气压，空气阀有蒸汽冒出时便可关闭空气阀。
6、 When the pressure in the pot rises to a little higher and the air pressure, the air valve can be closed when steam comes out of the air valve.
七、锅炉升压过程要按规定的要求，做好检查及各项操作确认正常后，才能进行供气或并炉。
7、 In the process of boiler pressurization, the gas supply or boiler combination can only be carried out after the inspection and operation are confirmed to be normal according to the specified requirements.
八、正常运行后，应经常调整供油、送风和给水（全自动锅炉除外），保持水位和气压稳定，适应负荷需要，保证供汽。
8、 After normal operation, oil supply, air supply and water supply (except for full-automatic boiler) shall be adjusted frequently to keep water level and air pressure stable, adapt to load demand and ensure steam supply.
九、运行中每小时应进行巡视检查一次，并按规定做好各项记录、签名确认。
9、 Patrol inspection shall be conducted every hour during operation, and all records and signatures shall be made according to regulations.
十、每班应进行冲洗水位表及排污各一次，阀排气试验压力表冲洗存水弯管和各项保护装置校验应按规定的要求进行，并如实填写记录、签名认可。
10、 Each shift shall flush the water level gauge and discharge the sewage once, the safety valve exhaust test, the pressure gauge flushing water storage elbow and the verification of various safety protection devices shall be carried out according to the specified requirements, and the records shall be filled in truthfully and signed for approval.
十一、正常停炉时要先停止供气，稍后停止送风，保持水位高于正常水位。
11、 When the boiler is shut down normally, the air supply should be stopped first, and then the air supply should be stopped to keep the water level higher than the normal water level.
The most important thing to buy products is quality, and choosing merchants is honesty. Shandong gas boiler sincerely provides excellent services for customers. Welcome to visit our website: http://www.jnlzsb.com Below message consultation
18678809986
